SlideShare ist ein Scribd-Unternehmen logo
1 von 70
Downloaden Sie, um offline zu lesen
THERMAL POWER PLANT (COAL TO POWER)
ELECTRICAL AND ELECTRONICS ENGINEERING DEPARTMENT
SIKKIM MANIPAL INSTITUTE 0F TECHNOLOGY
MAJITAR, RANGPO, EAST SIKKKIM-737136
INTRODUCTION
THERMAL POWER PLANT OVERVIEW
ELECTRICAL EQUIPMENTS AND CONCEPTS
 SLD AND FLOW CYCLES
SITE SELECTION FOR THERMAL POWER
PLANT
ADVANTAGES AND DISADVANTAGES
IN THIS PRESENTATION
• India is one of the world’s largest consumer of
energy
• Conventional sources: Thermal, Hydro and
Nuclear.
• Non- conventional: Wind, solar, Geothermal, tidal.
• Installed capacity – 1,61,352MW
– Thermal = 95151.74MW
– Nuclear = 4,120MW
– Hydro = 36877.76MW
– solar = 1324.41MW
• Annual power production – 680 billion KWH
INTRODUCTION
Break up of Power
• Thermal Power Plants – 75%
• Hydro Electric Power Plants - 20%
• Nuclear Power Plants - 4%
• Solar power plants – 1%
• Installed wind power Generation – 9655MW
• 30% to 40% of electrical power is lost in
transmission and distribution
OPERATIONAL FEATURES
INSIDE THE POWER PLANT
Coal
Chemical
Energy
Super Heated
Steam
Pollutants
Thermal
Energy
Turbine
Torque
Heat Loss
In
Condenser
Kinetic
Energy
Electrical
Energy
Alternating current
in Stator
Mech.
Energy LossASH
Heat
Loss
Elet. Energy
Loss
SIMPLE STEPS FOR ELECTRICITY GENERATION:
Operations In Thermal Power Station
Step wise operations in a thermal
power plant are as follows:-
Coal is used as a fuel to boil the
water.
Water is boiled to form
pressurized steam.
Pressurized steam is the force that
cause the turbine to rotate at a very
high speed.
Low pressure steam after pushing
through the turbine ,it’s going into
the condenser.
Condenser – the place where the
steam is condensed back it it’s liquid
form .Then the process is
repeated
Coal Storage
Coal Handling
Plant
Ash Storage
Ash Handling
Plant Boiler Super
Heater
Economizer
Air
Pre-heater
Generator ExciterTurbine
Chi
mne
y
Cooling
Tower
Make up
Water
Air
Coal
Ash
COAL
ASH
STEAM
WATER
FLUE GASES
Boiler feed
pump
CondenserCEP
Deaerator
ESP
Main parts of the plant are :
1. Coal handling Plant
2. DM Plant
3. Boiler
4. Super heater
5. Air preheater and
Economizer
6. Deaerator
7. Turbine
8. Condenser
9. Cooling towers
10. Electrostatic precipitator
11. Smoke stack(Chimney)
12. Generator
13. Transformers
14. Control room &
Switchyard
COMPONENTS
THERMAL POWER PLANT (COAL TO POWER)
Ground Hopper
V1 V2 V3
DRC
I/C
RSC
PRIMARY CRUSHER HOUSE
SECOND. CRUSHER HOUSE
SM
BUNKER
• DOUBLE ROLL CRUSHER
• IMPACT CRUSHER
• VIBRATING SCREEN
• CONVEYOR
• MAGNETIC SEPERATOR
• VIBRO FEEDERS
DOUBLE ROLL CHRUSHER
IMPACT CRUSHER CHP
VIBRATING SCREEN CHP-2
PROTECTION DEVICES ZERO SPEED
S/W, PULL CORD & BELT SWAY S/W
• ZSS:- Zero speed s/w is used to detect jamming/
slow speeding of motor, shaft & thereby
stopping the motor automatically.
• PULL CORD:- Pull cord switch also known as
Rope Operated Emergency switch is used as a
safety switch to stop the conveyor belt in case of
an emergency.
PROTECTION DEVICES ZERO SPEED
S/W, PULL CORD & BELT SWAY S/W
BSS:- Belt Sway Switch is a protective switch for
detecting the meandering (sway or deviation) of belt
conveyors, and sends out an alarm signal and an
emergency stop signal.
Suited to be used for belt breakage prevention when
running out of centre & overfeed prevention due to the
belt sway.
Emergency switch: it is present in the field. One can
operate it while some maintenance is going on.
DM PLANT
•The main aim of the DM Plant is to de-mineralize the
raw water coming from a water source (in this case
Kharu river nearby) from any mineral presence by
chemical dosing which may be harmful to the pipeline
and boilers.
•Cooling tower also comes under DM Plant.
Cooling Tower
• The warm water is taken from the
condenser tubes to about a quarter
of the way up the cooling tower.
• This breaks the water up into a
very fine spray, increasing the
surface area of the water droplets
making it easier to cool.
• The cooling tower is designed as a
natural draught chimney, drawing
cold air from outside through the
falling water.
• Cool water is collected in pond at
the bottom of the cooling tower.
• From here it is pumped back to
the condensers .
• To produce steam boiler converts
energy, in the form of coal, into steam
• The boiler is lined with steel tubing in
which pure boiler feed water is turned
to steam by the heat created from the
burning of coal
This plant contains two types of boilers
namely:
I. AFBC(Atmospheric Fluidized Bed
Combustion)
II. WHRB(Waste Heat Recovery Boiler)
Boiler
AFBC #1 =125TPH, 490 c,65kg/cm²
AFBC #2 =75 TPH, 490 c,65kg/cm²
WHRB #1=37TPH, 490 c,65kg/cm²
WHRB #2=37TPH, 490 c,65kg/cm²
WHRB#3=11.5TPH, 490 c,65kg/cm²
WHRB#4=11.5TPH, 490 c,65kg/cm²
Boiler details :
TPH=TONNES PER HOUR
Waste Heat Recovery
Boiler(WHRB):-
In this type the products of combustion
pass through the tubes which are
surrounded by water.
Atmospheric Fluidized Bed
Combustion(AFBC):-
In this type of boiler water flows inside
the tubes and hot gases flow outside the
tubes. These tubes are interconnected to
common water channels and to steam
outlet.
BOILERS:
•The AFBC boilers have many advantages over the WHRB
boilers
•High evaporation capacity due to availability of large heating
surface.
•Better heat transfer to the mass of water.
•Better efficiency of plant owing to rapid and uniform
circulation of water in tubes.
•Better overall control.
This fan forces the atmospheric air
through the boiler furnace and
pushes out the hot gases from the
furnace through superheater,
reheater, economizer and air heater
to stacks.
Forced Draught (FD) Fan
 Here a fan called ID fan is
provided at the outlet of boiler,
that is, just before the chimney.
This fan sucks hot gases from the
furnace through the superheaters,
economizer, reheater and
discharges gas into the chimney.
Induced Draught (ID) Fan
BOILER AUXILLARY :
Primary air fans (PA) are high pressure fans used to
supply the air for the transportation of coal directly to
the furnace .
Primary air (PA) fan:-
ECONOMISER
Flue gases coming out of the boiler carries
lot of heat.
ECONOMISER extracts a part of heat
from the flue gases and uses for heating the
feed water.
Thus improves efficiency of plant.
Temp. inside ECONOMISER is about 315
deg c.
SUPER HEATER
Super heater is used to remove the moisture content
from the steam.
Super heater raises the temperature of steam above 540 degree C.
Advantages of super heater
1. Increases efficiency
2. Reduces corrosion of turbine blades.
AIR PREHEATER
 It is used to preheat the air before entering
into furnace.
It is a heat exchanger in which some
further
heat is extracted from the flue gases and
use to heat the coming air for combustion.
THERMAL POWER PLANT (COAL TO POWER)
BOILER CIRCUIT WITH ELECTROSTATIC PRECIPITATOR
THERMAL POWER PLANT (COAL TO POWER)
•It is designed to trap and remove
dust particles from the exhaust
gas stream of an industrial
process.
•. Precipitators typically collect
99.9% or more of the dust from
the gas stream.
Corona Generation
Particle Charging
Particle Collection
Removal Of Particles
The Precipitation Process Involves
4 Main Functions:-
+++++++
-----------
+
+
+
+
+
+
+
-
-
-
-
-
-
-
+
+
+
+
+
+
+
-
-
-
-
-
-
-
+
+
+
+
+
+
+
-
-
-
-
-
-
+
+
+
+
+
+
+
-
-
-
-
-
-
-
collecting
rapperTransformer(415/60kv)
emitting
Toward
ID fan
Flue gas
Functions OF ESP
TO ASH SILO
CHIMNEY
CORONA
heavier ash
particles
lighter ash
particles
INLET = 80 g/m³ OUTLET = 50 mg/m³
DUST
LEVEL/STACK
LEVEL
ASH
SILO
INSULATOR
Main Components of Typical TG SET
consists of:
1. Permanent Magnet Generator
(PMG)
2. Automatic Voltage Regulator
(AVR)
3. BRUSHLESS EXCITER
4. GEAR BOX
5. ALTERNATER
6. TURBINE
TURBINE GENERATOR
EXCITER
GEAR
BOX
ALTENATOR
P
M
G
TURBINE
AVR
3 Ø
SUPPLY
TO LOAD
INLET TEMP = 484 5 C
INLET PRS = 62-65KG/cm²
SPEED= 7000 RPM
TURBINE GENERATOR SET
STEAM
coupling
PMG
3Ø
supply to
load
AVR
ɜ ɜ
3 Ø
AC
ɜ
ɜ
+
-
RECTIFIER
DC SUPPLY
DC SUPPLY
STATOR=MAGNETIC
FIELD
ROTOR= EMF STEAM
BRUSHLESS
EXCITER
ALTERNATOR
TURBINE
ROTOR= FIELD
STATOR =EMF
WORKING OF TUBINE GENERATOR
stator=
PM
Field
exciter
switch
ɜɜ
DVM
DFM
CC FREQUENCY CONTROLVOLTAGE CONTROL
INCREASE DECREASE INCREASE DECREASE
11KV
11.2KV
11.2KV
49.8 HZ50 HZ
50 HZ
TG SYNCHRONIZATION
11KV BUS
GRIDGEN
SKE relay
PHASE
NEUTRAL
SWITCH
OVERLOAD RELAY
CONTACTOR COIL
(K1)
STOP
NC
HOLDING
NO
DIRECT ONLINE STATER
START
NO
WORKING OF STAR DELTA STARTER
Y
R Y B
R
M
A2
A1 B1 C1
C2B2
Y B
CB
1250A
TG
3
TG
2
TG
1
CB
3150A
CB
1600A
11 KV BUS
SAT#1
11/6.6KV
387.8A
6.6KV BUS
415 V PCC
SAT#6
11/6.6KV
387.8A
SAT#2
11/6.6KV
387.8A
15 MW
18.75MVA
11KV
37 MW
46.25MVA
11KV
7.5 MW
10MVA
11KV
SAT# 3
6.6/433KV
218.7A
FERROSMS
AFBC#1
LOADS
AFBC#2
LOADS
WHRB’S
LOADS
KILNS
ELECTRICAL SLD FOR 60 MW
6.6 KV MOTORS
132 KV GRID
25 MVA
11/132 KV
TRAFOS
BC1BC2BC3BC4
CB
1600A
CB
1600A
CB
1600A
SAT# 4
6.6/433KV
218.7A
SAT# 5
6.6/433KV
218.7A
SAT# 5
6.6/433KV
218.7A
11KV/132 KV
s
GENERATOR
DISTRIBUTION
11KV/415V
TRANSFORMER
11 KV
RAIPUR BHILAI DURG BILASPURUTILIZATION
HOUSEINDUSTRIES MALLS /
SHOPS
11 KV
132KV/ 11KV
TRANSFORMER
11 KV
5/3/2013
OIL TANK
OVERHEAD
TANK
OIL
COOLER
LUBE OIL FILTER
TURBINE
GEAR
BOX
GEN
OIL
PUMP
Circulating Water Pumps
• The circulating water pumps are used
to circulate the water from the
cooling tower to the condenser and
back again
Boiler Feed Pump
• The boiler feed pump pumps water
into the boiler, overcoming the boiler
pressure of 160 bar to achieve it
• The pump is driven by a steam
turbine or an electric motor
• It runs at 7,000 revolutions per
minute
Low Pressure Feed Heaters
• Feed water from the condensate
extraction pumps passes through low
pressure feed heaters. Steam is used
to heat the feed water
• After the last feed heater, the feed
water is at around 160°C.
High Pressure Feed Heaters
• With a similar purpose to the low
pressure feed heaters, the high
pressure feed heaters are the last
stage of feed water heating before the
feed water enters the boiler system at
the economizer
• Feed water leaving these heaters is at
250°C
Condenser
• With its useful energy spent in the
turbines the steam then passes to
condensers
• Here it is condensed back into water
and pumped back to the boiler
• This happens via a series of low
pressure and high pressure feed
heaters
Condensate Extraction Pump
• The condensate water is drawn from
the condenser by the extraction pump
and sent to the low pressure feed
heaters
Deaerator
• A deaerator is a device that is
widely used for the removal of air
and other dissolved gases from
the feed water to steam-
generating boiler.
132 KV SWITCHYARD
47
Electrical switchyards are usually part of a substation
where electricity is transformed from one voltage to
another for the transmission, distribution.
48
MAIN COMPONENTS OF
SWITCHYARD
1.TRANSFORMER
2.CURRENT
TRANSFORMER
3.POTENTIAL
TRANSFORMER
4.CIRCUIT BREAKER
5.ISOLATOR
6.INSULATOR
7.LIGHTNING ARRESTOR
8.BUS BAR 49
TRANSFORMER
Transformer is the most
convenient device for transfer
of power from one voltage to
another voltage at the same
frequency. It works on the
principle of electromagnetic
induction.
50
Transformers are of two types:
STEP-UP TRANSFORMER –
Step-up the voltage at secondary side called step up transformer.
STEP-DOWN TRANSFORMER –
Step-down the voltage at secondary side are called step-down
transformer.
CT is a type of instrument transformer
that is used in power system for
measurement, detection, protection of
the system.
It is a device used to measure large
current by scaling large primary current
to a smaller , easy to measure,
secondary current.
51
CURRENT TRANSFORMER
POTENTIAL TRANSFORMER
These are used to step-down voltage for
measurement .
52
A circuit breaker is an
automatically-operated electrical
switch designed to protect an
electrical circuit from damage
caused by overload or short circuit.
Its basic function is to detect a
fault condition and, by interrupting
continuity, to immediately
discontinue electrical flow.
It can make or break a circuit
either manually or by remote
under normal or fault conditions.
53
CIRCUIT BREAKER
•It is a disconnection switch and to
be operated on no load.
•An isolator switch is used to make
sure that an electrical circuit can
be completely de-energized for
service or maintenance
54
ISOLATOR
It provide electrical
isolation of the
equipment, bus bar,
and circuit from the
live parts for
maintenance
purpose.
55
USES OF ISOLATOR
An insulator, also called a dielectric,
is a material that resists the flow of
electric
current.
In insulating materials
alliance electrons are tightly-
bonded to their atoms.
Insulator provides necessary
insulation between line
conductor and support.
56
INSULATOR
LIGHTNING ARRESTER
A lightning arrester is a device used on electrical power systems
to protect the insulation on the system from the damaging
effect of lightning
USES OF LIGHTNING ARRESTER
It protect the equipment from lightning stroke.
Lightning arrester is used to provide path to
unwanted excessive currents.
57
BUSBAR
Conductors to which a
number of circuits are
connected called bus-Bars.
In power plants, shut down
results disconnection of
supply to a large are.
Hence to avoid shut down
the major plants should
have elaborate bus bar
arrangement with duplicate
buses.
58
USES OF BUSBAR
Bus bar are used to carry
high current.
59
• Fuel used is cheaper
• Smaller space is required compared to hydro power
plant
• Economical in initial cost compared to hydro plants
and running costs are less compared to gas plants or
diesel plants
• Thermal plants can be placed near load centers unlike
hydro and nuclear plants. Hence transmission of
power losses can be minimized
• Thermal plants are able to respond to the load
demand more effectively and supports the
performance of the electrical grid
ADVANTAGES OF THERMAL POWER
PLANT
SITE SELECTION
• Transportation network: Easy and enough access to
transportation network is required in both power plant
construction and operation periods.
• Geology and soil type: The power plant should be built in an
area with soil and rock layers that could stand the weight and
vibrations of the power plant.
• Topography: It is proved that high elevation has a negative
effect on production efficiency of gas turbines. In addition,
changing of a sloping area into a flat site for the construction
of the power plant needs extra budget. Therefore, the
parameters of elevation and slope should be considered.
• Water resources: For the construction and operating of
power plant different volumes of water are required. This
could be supplied from either rivers or underground water
resources. Therefore having enough water supplies in
defined vicinity can be a factor in the selection of the site.
•Population centers: For the same reasons as above, the
site should have an enough distance from population
centers.
• Area size: Before any other consideration, the minimum
area size required for the construction of power plant
should be defined.
Thanks to
Mr. G.S. BHATIA(HOD POWER)
Mr. M. SUBBA RAO(G.M. ELECTRICAL)
Mr. B.D.MISHRA(Sr.DGM. C&I )
Mr. H.M.GUTPA(Sr.DGM. MECH )
Mr. N.V. SREENIVAS(Sr. DGM. OPERATION)
AND……
Special Thanks to:
Mr. B.L.VERMA(MANAGER)
Mr. D.CHAKRABARTY(DY. MANAGER)
Mr. U.K.CHOBEY(DY. MANAGER)
Mr. C.K.SONI (Sr. Engineer)
Mr. S SINGH (Sr. Engineer)
Mr. AMRINDER SANDHU(Engineer)
And all staffs & workers of power plant.
THERMAL POWER PLANT (COAL TO POWER)
DOUBLE ROLL CRUSHER
Material to be crushed:-Coal
Capacity :- 80TPH
Feed Size < 150mm
Product size < 50mm (90%)
RPM:- 173.73
Make:-SAYAJI/ELECON
TECHNICAL DETAIL OF I/CR
• CAPACITY :-75TPH
• SIZE:-1000Dia X 1000W
• MATERIAL :-Coal, Char
• FEED SIZE:-< 40mm
• PRODUCT SIZE:-< 6mm (65%)
• RPM:- 762
WORKING PRINCIPLES:
FARADAY’S LAW OF ELECTROMAGNETIC
INDUCTION.
WHEN EVER CONDUCTOR IS ROTATED IN MAGNETIC FILED,
EMF IS INDUCED WHICH ARE INDUCED EMF .
1) CONDUCTORS OF ELECTRICITY
2) MAGNETIC FIELD
3) CHANGE IN MAGNETIC FIELD
CORONA GENERATION
• DUE TO THE IONISATION OF GAS MOLECULES, + VE IONS, -VE IONS AND
FREE ELECTRONS ARE GENERATED.
ESP - PARTICLE CHARGING
• THE -VE CHARGES OF IONS AND FREE ELECTRONS TRAVEL TOWARDS +VE ELECTRODE AND THE
+VE CHARGES OF IONS TRAVEL TOWARDS -VE ELECTRODES.
• WHEN -VE IONS TRAVEL TOWARDS +VE ELECTRODES, THE -VE CHARGES GET ATTACHED TO THE
DUST PARTICLES AND THUS THE DUST PARTICLES ARE ELECTRICALLY CHARGED,

Weitere ähnliche Inhalte

Was ist angesagt?

thermal power plant PTTP Parichha
thermal power plant PTTP Parichhathermal power plant PTTP Parichha
thermal power plant PTTP ParichhaGagandeep Maan
 
rajwest thermal power plant
rajwest thermal power plantrajwest thermal power plant
rajwest thermal power plantRama Charan
 
power point presentation over thermal power plant
power point presentation over thermal power plantpower point presentation over thermal power plant
power point presentation over thermal power plantAnis Haider
 
SUMMER INTERNSHIP(INDUSTRAIL REPORT) ON THERMAL POWER PLANT
SUMMER INTERNSHIP(INDUSTRAIL REPORT) ON THERMAL POWER PLANT SUMMER INTERNSHIP(INDUSTRAIL REPORT) ON THERMAL POWER PLANT
SUMMER INTERNSHIP(INDUSTRAIL REPORT) ON THERMAL POWER PLANT Amit Gupta
 
Ash Handling System of a Thermal Power Plant
Ash Handling System of a Thermal Power PlantAsh Handling System of a Thermal Power Plant
Ash Handling System of a Thermal Power PlantAmay Jain
 
Coal based power plant
Coal based power plantCoal based power plant
Coal based power plantGaurav Kaushik
 
Thermal power plant
Thermal power plantThermal power plant
Thermal power plantVinay Garg
 
Coal power plant
Coal power plantCoal power plant
Coal power plantAnum Mairaj
 
Ash handling system
Ash handling systemAsh handling system
Ash handling systemVvs Pradeep
 
Condenser in thermal power plants
Condenser in thermal power plantsCondenser in thermal power plants
Condenser in thermal power plantsSHIVAJI CHOUDHURY
 
Thermal Power Plant - Manual
Thermal Power Plant - ManualThermal Power Plant - Manual
Thermal Power Plant - ManualSheel Shah
 
Mejia Thermal Power Station
Mejia Thermal Power StationMejia Thermal Power Station
Mejia Thermal Power Stationsagnikchoudhury
 
Thermal Plant report (Mechanical)
Thermal Plant report (Mechanical)Thermal Plant report (Mechanical)
Thermal Plant report (Mechanical)sometech
 
Report on Boilers at NTPC Ramagunadam
Report on  Boilers at NTPC RamagunadamReport on  Boilers at NTPC Ramagunadam
Report on Boilers at NTPC RamagunadamAbhinay Angari
 
Thermal power plant
Thermal power plantThermal power plant
Thermal power plantVivek Pathak
 
Construction of 500 MW Steam Boiler
Construction of 500 MW Steam BoilerConstruction of 500 MW Steam Boiler
Construction of 500 MW Steam BoilerVaibhav Paydelwar
 

Was ist angesagt? (20)

thermal power plant PTTP Parichha
thermal power plant PTTP Parichhathermal power plant PTTP Parichha
thermal power plant PTTP Parichha
 
rajwest thermal power plant
rajwest thermal power plantrajwest thermal power plant
rajwest thermal power plant
 
power point presentation over thermal power plant
power point presentation over thermal power plantpower point presentation over thermal power plant
power point presentation over thermal power plant
 
SUMMER INTERNSHIP(INDUSTRAIL REPORT) ON THERMAL POWER PLANT
SUMMER INTERNSHIP(INDUSTRAIL REPORT) ON THERMAL POWER PLANT SUMMER INTERNSHIP(INDUSTRAIL REPORT) ON THERMAL POWER PLANT
SUMMER INTERNSHIP(INDUSTRAIL REPORT) ON THERMAL POWER PLANT
 
Ash Handling System of a Thermal Power Plant
Ash Handling System of a Thermal Power PlantAsh Handling System of a Thermal Power Plant
Ash Handling System of a Thermal Power Plant
 
Coal based power plant
Coal based power plantCoal based power plant
Coal based power plant
 
Thermal power plant
Thermal power plantThermal power plant
Thermal power plant
 
Coal power plant
Coal power plantCoal power plant
Coal power plant
 
Ash handling system
Ash handling systemAsh handling system
Ash handling system
 
Condenser in thermal power plants
Condenser in thermal power plantsCondenser in thermal power plants
Condenser in thermal power plants
 
Thermal Power Plant - Manual
Thermal Power Plant - ManualThermal Power Plant - Manual
Thermal Power Plant - Manual
 
Mejia Thermal Power Station
Mejia Thermal Power StationMejia Thermal Power Station
Mejia Thermal Power Station
 
Thermal Plant report (Mechanical)
Thermal Plant report (Mechanical)Thermal Plant report (Mechanical)
Thermal Plant report (Mechanical)
 
Report on Boilers at NTPC Ramagunadam
Report on  Boilers at NTPC RamagunadamReport on  Boilers at NTPC Ramagunadam
Report on Boilers at NTPC Ramagunadam
 
An Overview of Thermal Power Plant
An Overview of Thermal Power PlantAn Overview of Thermal Power Plant
An Overview of Thermal Power Plant
 
Thermal power plant
Thermal power plantThermal power plant
Thermal power plant
 
Thermal Power Plant
Thermal Power PlantThermal Power Plant
Thermal Power Plant
 
Thermal power plant
Thermal power plantThermal power plant
Thermal power plant
 
Coal Power Plant
Coal Power PlantCoal Power Plant
Coal Power Plant
 
Construction of 500 MW Steam Boiler
Construction of 500 MW Steam BoilerConstruction of 500 MW Steam Boiler
Construction of 500 MW Steam Boiler
 

Andere mochten auch

Andere mochten auch (11)

bhushan steel ppt
bhushan steel pptbhushan steel ppt
bhushan steel ppt
 
WRM & BM
WRM & BMWRM & BM
WRM & BM
 
durgapur steel plant
 durgapur steel plant durgapur steel plant
durgapur steel plant
 
Thermal power plant
Thermal power plantThermal power plant
Thermal power plant
 
Blast furnace
Blast furnaceBlast furnace
Blast furnace
 
Industrial summer training at ntpc,badarpur
Industrial summer training at ntpc,badarpurIndustrial summer training at ntpc,badarpur
Industrial summer training at ntpc,badarpur
 
Summer training report on bhushan steels
Summer training report on bhushan steelsSummer training report on bhushan steels
Summer training report on bhushan steels
 
Industrial training at durgapur steel plant (instrumentation)
Industrial training at durgapur steel plant (instrumentation)Industrial training at durgapur steel plant (instrumentation)
Industrial training at durgapur steel plant (instrumentation)
 
Blast furnace presentation
Blast furnace presentation Blast furnace presentation
Blast furnace presentation
 
M1 seminar
M1 seminarM1 seminar
M1 seminar
 
Ntpc badarpur training ppt
Ntpc badarpur training pptNtpc badarpur training ppt
Ntpc badarpur training ppt
 

Ähnlich wie THERMAL POWER PLANT (COAL TO POWER)

Lakvijaya_Presentation1.pptx
Lakvijaya_Presentation1.pptxLakvijaya_Presentation1.pptx
Lakvijaya_Presentation1.pptxBhathiyaRanawaka
 
Vocational training at mejia thermal power plant
Vocational training at mejia thermal power plantVocational training at mejia thermal power plant
Vocational training at mejia thermal power plantNipak Banerjee
 
IPGCL/PPCL Training presentation
IPGCL/PPCL Training presentationIPGCL/PPCL Training presentation
IPGCL/PPCL Training presentationShubhra Dhyani
 
Ppt on power generation(thermal), transmission &amp; distribution
Ppt on power generation(thermal), transmission &amp; distributionPpt on power generation(thermal), transmission &amp; distribution
Ppt on power generation(thermal), transmission &amp; distributionSuvamSahu2
 
Ramendra summer training presentation
Ramendra summer training presentationRamendra summer training presentation
Ramendra summer training presentationRamendra Dhiman
 
Kota thermal power plant ppt
Kota thermal power plant pptKota thermal power plant ppt
Kota thermal power plant pptPrakash Jarotia
 
Presentation on THERMAL POWER PLANT
Presentation on THERMAL POWER PLANT Presentation on THERMAL POWER PLANT
Presentation on THERMAL POWER PLANT Abhijeet Thakur
 
Ppt of ajeet on suratgarh super thermal power station
Ppt of ajeet on suratgarh super thermal power stationPpt of ajeet on suratgarh super thermal power station
Ppt of ajeet on suratgarh super thermal power stationajeet singh choudhary
 
Durgapur Projects Limited: Vocational training presentation
Durgapur Projects Limited: Vocational training presentationDurgapur Projects Limited: Vocational training presentation
Durgapur Projects Limited: Vocational training presentationSaumyadip Moitra
 
KSTPS presentation.pptx
KSTPS presentation.pptxKSTPS presentation.pptx
KSTPS presentation.pptxParulChandna6
 
Ppt of internship at dccpp
Ppt of internship at dccppPpt of internship at dccpp
Ppt of internship at dccppDurgSingh
 
vocational training at DVC andal
 vocational training at DVC andal vocational training at DVC andal
vocational training at DVC andalANIL kumar
 
ppt on nspcl rourkela odisha
ppt on nspcl rourkela odishappt on nspcl rourkela odisha
ppt on nspcl rourkela odishaAnkitesh Maithil
 
Avdhehs kumar presention kstps kota
Avdhehs kumar presention kstps kotaAvdhehs kumar presention kstps kota
Avdhehs kumar presention kstps kotaAvdhesh kumar NIET
 

Ähnlich wie THERMAL POWER PLANT (COAL TO POWER) (20)

Htps
HtpsHtps
Htps
 
kstps training report
kstps training reportkstps training report
kstps training report
 
V.T ppt
V.T pptV.T ppt
V.T ppt
 
Lakvijaya_Presentation1.pptx
Lakvijaya_Presentation1.pptxLakvijaya_Presentation1.pptx
Lakvijaya_Presentation1.pptx
 
Vocational training at mejia thermal power plant
Vocational training at mejia thermal power plantVocational training at mejia thermal power plant
Vocational training at mejia thermal power plant
 
IPGCL/PPCL Training presentation
IPGCL/PPCL Training presentationIPGCL/PPCL Training presentation
IPGCL/PPCL Training presentation
 
Ppt on power generation(thermal), transmission &amp; distribution
Ppt on power generation(thermal), transmission &amp; distributionPpt on power generation(thermal), transmission &amp; distribution
Ppt on power generation(thermal), transmission &amp; distribution
 
Ramendra summer training presentation
Ramendra summer training presentationRamendra summer training presentation
Ramendra summer training presentation
 
ppt on kstps 2016
ppt on kstps 2016ppt on kstps 2016
ppt on kstps 2016
 
Kota thermal power plant ppt
Kota thermal power plant pptKota thermal power plant ppt
Kota thermal power plant ppt
 
Presentation on THERMAL POWER PLANT
Presentation on THERMAL POWER PLANT Presentation on THERMAL POWER PLANT
Presentation on THERMAL POWER PLANT
 
Ppt of ajeet on suratgarh super thermal power station
Ppt of ajeet on suratgarh super thermal power stationPpt of ajeet on suratgarh super thermal power station
Ppt of ajeet on suratgarh super thermal power station
 
Durgapur Projects Limited: Vocational training presentation
Durgapur Projects Limited: Vocational training presentationDurgapur Projects Limited: Vocational training presentation
Durgapur Projects Limited: Vocational training presentation
 
Dev
DevDev
Dev
 
KSTPS presentation.pptx
KSTPS presentation.pptxKSTPS presentation.pptx
KSTPS presentation.pptx
 
Ppt of internship at dccpp
Ppt of internship at dccppPpt of internship at dccpp
Ppt of internship at dccpp
 
vocational training at DVC andal
 vocational training at DVC andal vocational training at DVC andal
vocational training at DVC andal
 
ppt on nspcl rourkela odisha
ppt on nspcl rourkela odishappt on nspcl rourkela odisha
ppt on nspcl rourkela odisha
 
Kstps ppt
Kstps pptKstps ppt
Kstps ppt
 
Avdhehs kumar presention kstps kota
Avdhehs kumar presention kstps kotaAvdhehs kumar presention kstps kota
Avdhehs kumar presention kstps kota
 

Kürzlich hochgeladen

5 charts on South Africa as a source country for international student recrui...
5 charts on South Africa as a source country for international student recrui...5 charts on South Africa as a source country for international student recrui...
5 charts on South Africa as a source country for international student recrui...CaraSkikne1
 
The basics of sentences session 10pptx.pptx
The basics of sentences session 10pptx.pptxThe basics of sentences session 10pptx.pptx
The basics of sentences session 10pptx.pptxheathfieldcps1
 
ARTICULAR DISC OF TEMPOROMANDIBULAR JOINT
ARTICULAR DISC OF TEMPOROMANDIBULAR JOINTARTICULAR DISC OF TEMPOROMANDIBULAR JOINT
ARTICULAR DISC OF TEMPOROMANDIBULAR JOINTDR. SNEHA NAIR
 
Unveiling the Intricacies of Leishmania donovani: Structure, Life Cycle, Path...
Unveiling the Intricacies of Leishmania donovani: Structure, Life Cycle, Path...Unveiling the Intricacies of Leishmania donovani: Structure, Life Cycle, Path...
Unveiling the Intricacies of Leishmania donovani: Structure, Life Cycle, Path...Dr. Asif Anas
 
CapTechU Doctoral Presentation -March 2024 slides.pptx
CapTechU Doctoral Presentation -March 2024 slides.pptxCapTechU Doctoral Presentation -March 2024 slides.pptx
CapTechU Doctoral Presentation -March 2024 slides.pptxCapitolTechU
 
What is the Future of QuickBooks DeskTop?
What is the Future of QuickBooks DeskTop?What is the Future of QuickBooks DeskTop?
What is the Future of QuickBooks DeskTop?TechSoup
 
Quality Assurance_GOOD LABORATORY PRACTICE
Quality Assurance_GOOD LABORATORY PRACTICEQuality Assurance_GOOD LABORATORY PRACTICE
Quality Assurance_GOOD LABORATORY PRACTICESayali Powar
 
How to Create a Toggle Button in Odoo 17
How to Create a Toggle Button in Odoo 17How to Create a Toggle Button in Odoo 17
How to Create a Toggle Button in Odoo 17Celine George
 
A gentle introduction to Artificial Intelligence
A gentle introduction to Artificial IntelligenceA gentle introduction to Artificial Intelligence
A gentle introduction to Artificial IntelligenceApostolos Syropoulos
 
How to Add Existing Field in One2Many Tree View in Odoo 17
How to Add Existing Field in One2Many Tree View in Odoo 17How to Add Existing Field in One2Many Tree View in Odoo 17
How to Add Existing Field in One2Many Tree View in Odoo 17Celine George
 
EBUS5423 Data Analytics and Reporting Bl
EBUS5423 Data Analytics and Reporting BlEBUS5423 Data Analytics and Reporting Bl
EBUS5423 Data Analytics and Reporting BlDr. Bruce A. Johnson
 
How to Show Error_Warning Messages in Odoo 17
How to Show Error_Warning Messages in Odoo 17How to Show Error_Warning Messages in Odoo 17
How to Show Error_Warning Messages in Odoo 17Celine George
 
Diploma in Nursing Admission Test Question Solution 2023.pdf
Diploma in Nursing Admission Test Question Solution 2023.pdfDiploma in Nursing Admission Test Question Solution 2023.pdf
Diploma in Nursing Admission Test Question Solution 2023.pdfMohonDas
 
Vani Magazine - Quarterly Magazine of Seshadripuram Educational Trust
Vani Magazine - Quarterly Magazine of Seshadripuram Educational TrustVani Magazine - Quarterly Magazine of Seshadripuram Educational Trust
Vani Magazine - Quarterly Magazine of Seshadripuram Educational TrustSavipriya Raghavendra
 
In - Vivo and In - Vitro Correlation.pptx
In - Vivo and In - Vitro Correlation.pptxIn - Vivo and In - Vitro Correlation.pptx
In - Vivo and In - Vitro Correlation.pptxAditiChauhan701637
 
Slides CapTechTalks Webinar March 2024 Joshua Sinai.pptx
Slides CapTechTalks Webinar March 2024 Joshua Sinai.pptxSlides CapTechTalks Webinar March 2024 Joshua Sinai.pptx
Slides CapTechTalks Webinar March 2024 Joshua Sinai.pptxCapitolTechU
 
Over the counter (OTC)- Sale, rational use.pptx
Over the counter (OTC)- Sale, rational use.pptxOver the counter (OTC)- Sale, rational use.pptx
Over the counter (OTC)- Sale, rational use.pptxraviapr7
 
DUST OF SNOW_BY ROBERT FROST_EDITED BY_ TANMOY MISHRA
DUST OF SNOW_BY ROBERT FROST_EDITED BY_ TANMOY MISHRADUST OF SNOW_BY ROBERT FROST_EDITED BY_ TANMOY MISHRA
DUST OF SNOW_BY ROBERT FROST_EDITED BY_ TANMOY MISHRATanmoy Mishra
 
Prescribed medication order and communication skills.pptx
Prescribed medication order and communication skills.pptxPrescribed medication order and communication skills.pptx
Prescribed medication order and communication skills.pptxraviapr7
 

Kürzlich hochgeladen (20)

5 charts on South Africa as a source country for international student recrui...
5 charts on South Africa as a source country for international student recrui...5 charts on South Africa as a source country for international student recrui...
5 charts on South Africa as a source country for international student recrui...
 
The basics of sentences session 10pptx.pptx
The basics of sentences session 10pptx.pptxThe basics of sentences session 10pptx.pptx
The basics of sentences session 10pptx.pptx
 
ARTICULAR DISC OF TEMPOROMANDIBULAR JOINT
ARTICULAR DISC OF TEMPOROMANDIBULAR JOINTARTICULAR DISC OF TEMPOROMANDIBULAR JOINT
ARTICULAR DISC OF TEMPOROMANDIBULAR JOINT
 
Unveiling the Intricacies of Leishmania donovani: Structure, Life Cycle, Path...
Unveiling the Intricacies of Leishmania donovani: Structure, Life Cycle, Path...Unveiling the Intricacies of Leishmania donovani: Structure, Life Cycle, Path...
Unveiling the Intricacies of Leishmania donovani: Structure, Life Cycle, Path...
 
CapTechU Doctoral Presentation -March 2024 slides.pptx
CapTechU Doctoral Presentation -March 2024 slides.pptxCapTechU Doctoral Presentation -March 2024 slides.pptx
CapTechU Doctoral Presentation -March 2024 slides.pptx
 
What is the Future of QuickBooks DeskTop?
What is the Future of QuickBooks DeskTop?What is the Future of QuickBooks DeskTop?
What is the Future of QuickBooks DeskTop?
 
Quality Assurance_GOOD LABORATORY PRACTICE
Quality Assurance_GOOD LABORATORY PRACTICEQuality Assurance_GOOD LABORATORY PRACTICE
Quality Assurance_GOOD LABORATORY PRACTICE
 
How to Create a Toggle Button in Odoo 17
How to Create a Toggle Button in Odoo 17How to Create a Toggle Button in Odoo 17
How to Create a Toggle Button in Odoo 17
 
A gentle introduction to Artificial Intelligence
A gentle introduction to Artificial IntelligenceA gentle introduction to Artificial Intelligence
A gentle introduction to Artificial Intelligence
 
How to Add Existing Field in One2Many Tree View in Odoo 17
How to Add Existing Field in One2Many Tree View in Odoo 17How to Add Existing Field in One2Many Tree View in Odoo 17
How to Add Existing Field in One2Many Tree View in Odoo 17
 
EBUS5423 Data Analytics and Reporting Bl
EBUS5423 Data Analytics and Reporting BlEBUS5423 Data Analytics and Reporting Bl
EBUS5423 Data Analytics and Reporting Bl
 
How to Show Error_Warning Messages in Odoo 17
How to Show Error_Warning Messages in Odoo 17How to Show Error_Warning Messages in Odoo 17
How to Show Error_Warning Messages in Odoo 17
 
Diploma in Nursing Admission Test Question Solution 2023.pdf
Diploma in Nursing Admission Test Question Solution 2023.pdfDiploma in Nursing Admission Test Question Solution 2023.pdf
Diploma in Nursing Admission Test Question Solution 2023.pdf
 
Vani Magazine - Quarterly Magazine of Seshadripuram Educational Trust
Vani Magazine - Quarterly Magazine of Seshadripuram Educational TrustVani Magazine - Quarterly Magazine of Seshadripuram Educational Trust
Vani Magazine - Quarterly Magazine of Seshadripuram Educational Trust
 
In - Vivo and In - Vitro Correlation.pptx
In - Vivo and In - Vitro Correlation.pptxIn - Vivo and In - Vitro Correlation.pptx
In - Vivo and In - Vitro Correlation.pptx
 
Slides CapTechTalks Webinar March 2024 Joshua Sinai.pptx
Slides CapTechTalks Webinar March 2024 Joshua Sinai.pptxSlides CapTechTalks Webinar March 2024 Joshua Sinai.pptx
Slides CapTechTalks Webinar March 2024 Joshua Sinai.pptx
 
Over the counter (OTC)- Sale, rational use.pptx
Over the counter (OTC)- Sale, rational use.pptxOver the counter (OTC)- Sale, rational use.pptx
Over the counter (OTC)- Sale, rational use.pptx
 
DUST OF SNOW_BY ROBERT FROST_EDITED BY_ TANMOY MISHRA
DUST OF SNOW_BY ROBERT FROST_EDITED BY_ TANMOY MISHRADUST OF SNOW_BY ROBERT FROST_EDITED BY_ TANMOY MISHRA
DUST OF SNOW_BY ROBERT FROST_EDITED BY_ TANMOY MISHRA
 
Prescribed medication order and communication skills.pptx
Prescribed medication order and communication skills.pptxPrescribed medication order and communication skills.pptx
Prescribed medication order and communication skills.pptx
 
Personal Resilience in Project Management 2 - TV Edit 1a.pdf
Personal Resilience in Project Management 2 - TV Edit 1a.pdfPersonal Resilience in Project Management 2 - TV Edit 1a.pdf
Personal Resilience in Project Management 2 - TV Edit 1a.pdf
 

THERMAL POWER PLANT (COAL TO POWER)

  • 2. ELECTRICAL AND ELECTRONICS ENGINEERING DEPARTMENT SIKKIM MANIPAL INSTITUTE 0F TECHNOLOGY MAJITAR, RANGPO, EAST SIKKKIM-737136
  • 3. INTRODUCTION THERMAL POWER PLANT OVERVIEW ELECTRICAL EQUIPMENTS AND CONCEPTS  SLD AND FLOW CYCLES SITE SELECTION FOR THERMAL POWER PLANT ADVANTAGES AND DISADVANTAGES IN THIS PRESENTATION
  • 4. • India is one of the world’s largest consumer of energy • Conventional sources: Thermal, Hydro and Nuclear. • Non- conventional: Wind, solar, Geothermal, tidal. • Installed capacity – 1,61,352MW – Thermal = 95151.74MW – Nuclear = 4,120MW – Hydro = 36877.76MW – solar = 1324.41MW • Annual power production – 680 billion KWH INTRODUCTION
  • 5. Break up of Power • Thermal Power Plants – 75% • Hydro Electric Power Plants - 20% • Nuclear Power Plants - 4% • Solar power plants – 1% • Installed wind power Generation – 9655MW • 30% to 40% of electrical power is lost in transmission and distribution
  • 7. Coal Chemical Energy Super Heated Steam Pollutants Thermal Energy Turbine Torque Heat Loss In Condenser Kinetic Energy Electrical Energy Alternating current in Stator Mech. Energy LossASH Heat Loss Elet. Energy Loss SIMPLE STEPS FOR ELECTRICITY GENERATION:
  • 8. Operations In Thermal Power Station Step wise operations in a thermal power plant are as follows:- Coal is used as a fuel to boil the water. Water is boiled to form pressurized steam. Pressurized steam is the force that cause the turbine to rotate at a very high speed. Low pressure steam after pushing through the turbine ,it’s going into the condenser. Condenser – the place where the steam is condensed back it it’s liquid form .Then the process is repeated
  • 9. Coal Storage Coal Handling Plant Ash Storage Ash Handling Plant Boiler Super Heater Economizer Air Pre-heater Generator ExciterTurbine Chi mne y Cooling Tower Make up Water Air Coal Ash COAL ASH STEAM WATER FLUE GASES Boiler feed pump CondenserCEP Deaerator ESP
  • 10. Main parts of the plant are : 1. Coal handling Plant 2. DM Plant 3. Boiler 4. Super heater 5. Air preheater and Economizer 6. Deaerator 7. Turbine 8. Condenser 9. Cooling towers 10. Electrostatic precipitator 11. Smoke stack(Chimney) 12. Generator 13. Transformers 14. Control room & Switchyard COMPONENTS
  • 12. Ground Hopper V1 V2 V3 DRC I/C RSC PRIMARY CRUSHER HOUSE SECOND. CRUSHER HOUSE SM BUNKER
  • 13. • DOUBLE ROLL CRUSHER • IMPACT CRUSHER • VIBRATING SCREEN • CONVEYOR • MAGNETIC SEPERATOR • VIBRO FEEDERS
  • 17. PROTECTION DEVICES ZERO SPEED S/W, PULL CORD & BELT SWAY S/W
  • 18. • ZSS:- Zero speed s/w is used to detect jamming/ slow speeding of motor, shaft & thereby stopping the motor automatically. • PULL CORD:- Pull cord switch also known as Rope Operated Emergency switch is used as a safety switch to stop the conveyor belt in case of an emergency. PROTECTION DEVICES ZERO SPEED S/W, PULL CORD & BELT SWAY S/W
  • 19. BSS:- Belt Sway Switch is a protective switch for detecting the meandering (sway or deviation) of belt conveyors, and sends out an alarm signal and an emergency stop signal. Suited to be used for belt breakage prevention when running out of centre & overfeed prevention due to the belt sway. Emergency switch: it is present in the field. One can operate it while some maintenance is going on.
  • 20. DM PLANT •The main aim of the DM Plant is to de-mineralize the raw water coming from a water source (in this case Kharu river nearby) from any mineral presence by chemical dosing which may be harmful to the pipeline and boilers. •Cooling tower also comes under DM Plant.
  • 21. Cooling Tower • The warm water is taken from the condenser tubes to about a quarter of the way up the cooling tower. • This breaks the water up into a very fine spray, increasing the surface area of the water droplets making it easier to cool. • The cooling tower is designed as a natural draught chimney, drawing cold air from outside through the falling water. • Cool water is collected in pond at the bottom of the cooling tower. • From here it is pumped back to the condensers .
  • 22. • To produce steam boiler converts energy, in the form of coal, into steam • The boiler is lined with steel tubing in which pure boiler feed water is turned to steam by the heat created from the burning of coal This plant contains two types of boilers namely: I. AFBC(Atmospheric Fluidized Bed Combustion) II. WHRB(Waste Heat Recovery Boiler) Boiler
  • 23. AFBC #1 =125TPH, 490 c,65kg/cm² AFBC #2 =75 TPH, 490 c,65kg/cm² WHRB #1=37TPH, 490 c,65kg/cm² WHRB #2=37TPH, 490 c,65kg/cm² WHRB#3=11.5TPH, 490 c,65kg/cm² WHRB#4=11.5TPH, 490 c,65kg/cm² Boiler details : TPH=TONNES PER HOUR
  • 24. Waste Heat Recovery Boiler(WHRB):- In this type the products of combustion pass through the tubes which are surrounded by water. Atmospheric Fluidized Bed Combustion(AFBC):- In this type of boiler water flows inside the tubes and hot gases flow outside the tubes. These tubes are interconnected to common water channels and to steam outlet. BOILERS: •The AFBC boilers have many advantages over the WHRB boilers •High evaporation capacity due to availability of large heating surface. •Better heat transfer to the mass of water. •Better efficiency of plant owing to rapid and uniform circulation of water in tubes. •Better overall control.
  • 25. This fan forces the atmospheric air through the boiler furnace and pushes out the hot gases from the furnace through superheater, reheater, economizer and air heater to stacks. Forced Draught (FD) Fan  Here a fan called ID fan is provided at the outlet of boiler, that is, just before the chimney. This fan sucks hot gases from the furnace through the superheaters, economizer, reheater and discharges gas into the chimney. Induced Draught (ID) Fan BOILER AUXILLARY : Primary air fans (PA) are high pressure fans used to supply the air for the transportation of coal directly to the furnace . Primary air (PA) fan:-
  • 26. ECONOMISER Flue gases coming out of the boiler carries lot of heat. ECONOMISER extracts a part of heat from the flue gases and uses for heating the feed water. Thus improves efficiency of plant. Temp. inside ECONOMISER is about 315 deg c.
  • 27. SUPER HEATER Super heater is used to remove the moisture content from the steam. Super heater raises the temperature of steam above 540 degree C. Advantages of super heater 1. Increases efficiency 2. Reduces corrosion of turbine blades.
  • 28. AIR PREHEATER  It is used to preheat the air before entering into furnace. It is a heat exchanger in which some further heat is extracted from the flue gases and use to heat the coming air for combustion.
  • 30. BOILER CIRCUIT WITH ELECTROSTATIC PRECIPITATOR
  • 32. •It is designed to trap and remove dust particles from the exhaust gas stream of an industrial process. •. Precipitators typically collect 99.9% or more of the dust from the gas stream.
  • 33. Corona Generation Particle Charging Particle Collection Removal Of Particles The Precipitation Process Involves 4 Main Functions:-
  • 34. +++++++ ----------- + + + + + + + - - - - - - - + + + + + + + - - - - - - - + + + + + + + - - - - - - + + + + + + + - - - - - - - collecting rapperTransformer(415/60kv) emitting Toward ID fan Flue gas Functions OF ESP TO ASH SILO CHIMNEY CORONA heavier ash particles lighter ash particles INLET = 80 g/m³ OUTLET = 50 mg/m³ DUST LEVEL/STACK LEVEL ASH SILO INSULATOR
  • 35. Main Components of Typical TG SET consists of: 1. Permanent Magnet Generator (PMG) 2. Automatic Voltage Regulator (AVR) 3. BRUSHLESS EXCITER 4. GEAR BOX 5. ALTERNATER 6. TURBINE TURBINE GENERATOR
  • 36. EXCITER GEAR BOX ALTENATOR P M G TURBINE AVR 3 Ø SUPPLY TO LOAD INLET TEMP = 484 5 C INLET PRS = 62-65KG/cm² SPEED= 7000 RPM TURBINE GENERATOR SET STEAM coupling
  • 37. PMG 3Ø supply to load AVR ɜ ɜ 3 Ø AC ɜ ɜ + - RECTIFIER DC SUPPLY DC SUPPLY STATOR=MAGNETIC FIELD ROTOR= EMF STEAM BRUSHLESS EXCITER ALTERNATOR TURBINE ROTOR= FIELD STATOR =EMF WORKING OF TUBINE GENERATOR stator= PM Field exciter switch
  • 38. ɜɜ DVM DFM CC FREQUENCY CONTROLVOLTAGE CONTROL INCREASE DECREASE INCREASE DECREASE 11KV 11.2KV 11.2KV 49.8 HZ50 HZ 50 HZ TG SYNCHRONIZATION 11KV BUS GRIDGEN SKE relay
  • 40. WORKING OF STAR DELTA STARTER Y R Y B R M A2 A1 B1 C1 C2B2 Y B
  • 41. CB 1250A TG 3 TG 2 TG 1 CB 3150A CB 1600A 11 KV BUS SAT#1 11/6.6KV 387.8A 6.6KV BUS 415 V PCC SAT#6 11/6.6KV 387.8A SAT#2 11/6.6KV 387.8A 15 MW 18.75MVA 11KV 37 MW 46.25MVA 11KV 7.5 MW 10MVA 11KV SAT# 3 6.6/433KV 218.7A FERROSMS AFBC#1 LOADS AFBC#2 LOADS WHRB’S LOADS KILNS ELECTRICAL SLD FOR 60 MW 6.6 KV MOTORS 132 KV GRID 25 MVA 11/132 KV TRAFOS BC1BC2BC3BC4 CB 1600A CB 1600A CB 1600A SAT# 4 6.6/433KV 218.7A SAT# 5 6.6/433KV 218.7A SAT# 5 6.6/433KV 218.7A
  • 42. 11KV/132 KV s GENERATOR DISTRIBUTION 11KV/415V TRANSFORMER 11 KV RAIPUR BHILAI DURG BILASPURUTILIZATION HOUSEINDUSTRIES MALLS / SHOPS 11 KV 132KV/ 11KV TRANSFORMER 11 KV 5/3/2013
  • 43. OIL TANK OVERHEAD TANK OIL COOLER LUBE OIL FILTER TURBINE GEAR BOX GEN OIL PUMP
  • 44. Circulating Water Pumps • The circulating water pumps are used to circulate the water from the cooling tower to the condenser and back again Boiler Feed Pump • The boiler feed pump pumps water into the boiler, overcoming the boiler pressure of 160 bar to achieve it • The pump is driven by a steam turbine or an electric motor • It runs at 7,000 revolutions per minute
  • 45. Low Pressure Feed Heaters • Feed water from the condensate extraction pumps passes through low pressure feed heaters. Steam is used to heat the feed water • After the last feed heater, the feed water is at around 160°C. High Pressure Feed Heaters • With a similar purpose to the low pressure feed heaters, the high pressure feed heaters are the last stage of feed water heating before the feed water enters the boiler system at the economizer • Feed water leaving these heaters is at 250°C
  • 46. Condenser • With its useful energy spent in the turbines the steam then passes to condensers • Here it is condensed back into water and pumped back to the boiler • This happens via a series of low pressure and high pressure feed heaters Condensate Extraction Pump • The condensate water is drawn from the condenser by the extraction pump and sent to the low pressure feed heaters Deaerator • A deaerator is a device that is widely used for the removal of air and other dissolved gases from the feed water to steam- generating boiler.
  • 48. Electrical switchyards are usually part of a substation where electricity is transformed from one voltage to another for the transmission, distribution. 48
  • 49. MAIN COMPONENTS OF SWITCHYARD 1.TRANSFORMER 2.CURRENT TRANSFORMER 3.POTENTIAL TRANSFORMER 4.CIRCUIT BREAKER 5.ISOLATOR 6.INSULATOR 7.LIGHTNING ARRESTOR 8.BUS BAR 49
  • 50. TRANSFORMER Transformer is the most convenient device for transfer of power from one voltage to another voltage at the same frequency. It works on the principle of electromagnetic induction. 50 Transformers are of two types: STEP-UP TRANSFORMER – Step-up the voltage at secondary side called step up transformer. STEP-DOWN TRANSFORMER – Step-down the voltage at secondary side are called step-down transformer.
  • 51. CT is a type of instrument transformer that is used in power system for measurement, detection, protection of the system. It is a device used to measure large current by scaling large primary current to a smaller , easy to measure, secondary current. 51 CURRENT TRANSFORMER
  • 52. POTENTIAL TRANSFORMER These are used to step-down voltage for measurement . 52
  • 53. A circuit breaker is an automatically-operated electrical switch designed to protect an electrical circuit from damage caused by overload or short circuit. Its basic function is to detect a fault condition and, by interrupting continuity, to immediately discontinue electrical flow. It can make or break a circuit either manually or by remote under normal or fault conditions. 53 CIRCUIT BREAKER
  • 54. •It is a disconnection switch and to be operated on no load. •An isolator switch is used to make sure that an electrical circuit can be completely de-energized for service or maintenance 54 ISOLATOR
  • 55. It provide electrical isolation of the equipment, bus bar, and circuit from the live parts for maintenance purpose. 55 USES OF ISOLATOR
  • 56. An insulator, also called a dielectric, is a material that resists the flow of electric current. In insulating materials alliance electrons are tightly- bonded to their atoms. Insulator provides necessary insulation between line conductor and support. 56 INSULATOR
  • 57. LIGHTNING ARRESTER A lightning arrester is a device used on electrical power systems to protect the insulation on the system from the damaging effect of lightning USES OF LIGHTNING ARRESTER It protect the equipment from lightning stroke. Lightning arrester is used to provide path to unwanted excessive currents. 57
  • 58. BUSBAR Conductors to which a number of circuits are connected called bus-Bars. In power plants, shut down results disconnection of supply to a large are. Hence to avoid shut down the major plants should have elaborate bus bar arrangement with duplicate buses. 58
  • 59. USES OF BUSBAR Bus bar are used to carry high current. 59
  • 60. • Fuel used is cheaper • Smaller space is required compared to hydro power plant • Economical in initial cost compared to hydro plants and running costs are less compared to gas plants or diesel plants • Thermal plants can be placed near load centers unlike hydro and nuclear plants. Hence transmission of power losses can be minimized • Thermal plants are able to respond to the load demand more effectively and supports the performance of the electrical grid ADVANTAGES OF THERMAL POWER PLANT
  • 61. SITE SELECTION • Transportation network: Easy and enough access to transportation network is required in both power plant construction and operation periods. • Geology and soil type: The power plant should be built in an area with soil and rock layers that could stand the weight and vibrations of the power plant. • Topography: It is proved that high elevation has a negative effect on production efficiency of gas turbines. In addition, changing of a sloping area into a flat site for the construction of the power plant needs extra budget. Therefore, the parameters of elevation and slope should be considered.
  • 62. • Water resources: For the construction and operating of power plant different volumes of water are required. This could be supplied from either rivers or underground water resources. Therefore having enough water supplies in defined vicinity can be a factor in the selection of the site. •Population centers: For the same reasons as above, the site should have an enough distance from population centers. • Area size: Before any other consideration, the minimum area size required for the construction of power plant should be defined.
  • 63. Thanks to Mr. G.S. BHATIA(HOD POWER) Mr. M. SUBBA RAO(G.M. ELECTRICAL) Mr. B.D.MISHRA(Sr.DGM. C&I ) Mr. H.M.GUTPA(Sr.DGM. MECH ) Mr. N.V. SREENIVAS(Sr. DGM. OPERATION)
  • 64. AND…… Special Thanks to: Mr. B.L.VERMA(MANAGER) Mr. D.CHAKRABARTY(DY. MANAGER) Mr. U.K.CHOBEY(DY. MANAGER) Mr. C.K.SONI (Sr. Engineer) Mr. S SINGH (Sr. Engineer) Mr. AMRINDER SANDHU(Engineer) And all staffs & workers of power plant.
  • 66. DOUBLE ROLL CRUSHER Material to be crushed:-Coal Capacity :- 80TPH Feed Size < 150mm Product size < 50mm (90%) RPM:- 173.73 Make:-SAYAJI/ELECON
  • 67. TECHNICAL DETAIL OF I/CR • CAPACITY :-75TPH • SIZE:-1000Dia X 1000W • MATERIAL :-Coal, Char • FEED SIZE:-< 40mm • PRODUCT SIZE:-< 6mm (65%) • RPM:- 762
  • 68. WORKING PRINCIPLES: FARADAY’S LAW OF ELECTROMAGNETIC INDUCTION. WHEN EVER CONDUCTOR IS ROTATED IN MAGNETIC FILED, EMF IS INDUCED WHICH ARE INDUCED EMF . 1) CONDUCTORS OF ELECTRICITY 2) MAGNETIC FIELD 3) CHANGE IN MAGNETIC FIELD
  • 69. CORONA GENERATION • DUE TO THE IONISATION OF GAS MOLECULES, + VE IONS, -VE IONS AND FREE ELECTRONS ARE GENERATED.
  • 70. ESP - PARTICLE CHARGING • THE -VE CHARGES OF IONS AND FREE ELECTRONS TRAVEL TOWARDS +VE ELECTRODE AND THE +VE CHARGES OF IONS TRAVEL TOWARDS -VE ELECTRODES. • WHEN -VE IONS TRAVEL TOWARDS +VE ELECTRODES, THE -VE CHARGES GET ATTACHED TO THE DUST PARTICLES AND THUS THE DUST PARTICLES ARE ELECTRICALLY CHARGED,